Audi 2.0 TFSI Engine Oil Consumption – Correction

What is the problem? The early version of the TFSI gasoline engines found in the A5, A4 and Q5 have an inherent design fault which leads to high consumption of oil. The base problem seems to relate to the piston rings, which allow small amounts of oil to leak round the pistons into the cylinders, where it burns and therefore leads to high oil consumption. The typical way drivers become aware of this is when the 'add one litre of oil' notice comes up on the dashboard. When this comes up you don't need to immediately stop, but you should add [...]

By | April 13th, 2017|Case Studies|Comments Off on Audi 2.0 TFSI Engine Oil Consumption – Correction

Volvo and Land Rover Differential Problems – Out Of Town – We’ll Repair – Send To Us

The Problem This 2010 Volvo XC70 came to us with about 96K miles, and a loud noise coming from the rear of the vehicle. The noise was noticeable at low and moderate speeds while driving, and sounded like a loud whine or hum depending on vehicle speed. Initially this noise sounded like a defective wheel bearing but on further exam we determined the noise was in fact coming from the rear differential, the gear system that transmits force from the transmission to the rear wheels. We've seen this before, both on the later model Volvo and the Land Rover LR2 vehicles, and [...]

By | April 11th, 2017|Case Studies|Comments Off on Volvo and Land Rover Differential Problems – Out Of Town – We’ll Repair – Send To Us

The Measure Of A Workshop – Or How To Find A New Home For Your Car

To Start For sometime now I’ve been involved with other shops, either in a consulting, or in an industry 20 Group. Over the years I’ve developed a set of criteria that I’ve shared with friends and family about how to properly evaluate where to obtain high quality, ethical auto service. These apply if your auto is an Audi, BMW, Mercedes, Lexus, Saab, Volvo or VW. Some of these items may seem basic, even commonsense, but all too often folks make the decision of where to take the car under duress, you want to have an ongoing relationship with shop before [...]

By | March 3rd, 2016|Case Studies|Comments Off on The Measure Of A Workshop – Or How To Find A New Home For Your Car

Washer Solvent Warning Light Sensors and Rain X Deicer

Low Washer Fluid Warning The Problem Have you experienced a washer low level light that seems to stay on all the time, or worse yet, doesn't come on at all, even when the fluid is low or empty? This is something we are seeing more and more often, now that the New England snows have finally left us, problems with the fluid level sensors in customer car's washer solvent bottles. The problem seems to occur across the car lines we service, and doesn't seem to matter what kind of car, we've seen it in Audi, BMW, Mercedes, and Volkswagen. [...]

By | April 14th, 2015|Case Studies|Comments Off on Washer Solvent Warning Light Sensors and Rain X Deicer

BMW Engine – When Good Oil Pans, Go Bad – Oil Leaks

Drive Oil Level Data I title this when "Good Oil Pans Go Bad" to illustrate a point, 99% of the time, the engine oil pan does nothing but hold your engine's oil, but when the gasket between the engine block and pan fails, it's a bad thing. What Aside from the engine oil leak making a mess in your garage or parking space, and possible engine damage from low oil level, that oil has a nasty habit of finding it's way to your engine's catalytic convertor. Oil on a very hot item like a convertor at speed, aside [...]

By | March 13th, 2015|Case Studies|Comments Off on BMW Engine – When Good Oil Pans, Go Bad – Oil Leaks

Headlight Lens Refinishing – We Do That – Save Money And See Better

Tech Tip - Headlight Lens Refinishing – Save Money And See Better – Headlight refinishing - Volvo. We can do the same on Audi, BMW, Mercedes, Mini Cooper, Saab and Lexus. How many of you get in your car that’s a few years older now and find that your headlights are no longer shining like they used to? More and more cars have gone from glass headlight housings to plastic ones for cheaper production costs and weight reduction. One side affect we see more with lights of this type is heavy pitting and discoloration from the natural elements we [...]

By | March 5th, 2015|Case Studies|Comments Off on Headlight Lens Refinishing – We Do That – Save Money And See Better